-
Common failures of unit operation
In the daily use of diesel engine generator sets, some common failures directly affect the service life and production efficiency of diesel engine. So it is very important to understand the fault of diesel engine. Below, we introduce the common fault of diesel engine and fault reason analysis. D...Read more -
2021 Taizhou Industry Expo (TIE)
Your Like Power (Fuzhou) Co.,Ltd attended the 2021 Taizhou Industry Expo (TIE) in Taizhou International Convention and Exhibition Center at July 31st -August 1st ,2021. The exhibits of our company are motor housings for air compressors and general motors.The two products attracted the interest a...Read more -
The adjustment of advance Angle on the diesel engine fuel injection
In order to obtain good combustion, make the diesel engine run normally and get the most economical fuel consumption, the injection advance Angle must be adjusted < fuel supply advance Angle 28 — 31 degrees and injection advance Angle 20–23 degrees > during installation after th...Read more -
The 21th China International Electric Motor Expo and Forum
Your Like Power (Fuzhou) Co.,Ltd attended the 21th China International Electric Motor Expo and Forum in Shanghai New International Expo Centre at June 27-29,2021. 2021 the 21st session of China international exposition and electrical development BBS by GUO HAO exhibition (Shanghai) co., LTD., to...Read more -
What are the effects of ambient temperature on the power of diesel generator sets?
No matter what brand, imported or domestic diesel generator sets, their operation will be affected by the working environment. The three environmental factors, altitude, temperature and humidity, have a particularly obvious impact on the diesel generator set: 1.Altitude. The general use of diesel...Read more -
Failure analysis and solution for Diesel engine oil pressure is low
Failure Analysis: A.. Oil level is low in oil sump. B. The oil pressure regulator spring fracture; C. Oil filter rubber mat aging oil leakage D. Oil pressure meter broken E. The oil filter in oil sump clogging. Troubleshooting A. Keep the oil sump oil in static full scale, timely to add oil B. R...Read more -
The fault alarm and solution of diesel generator control panel
Power backup diesel genset can not start and stop automatically Failure Analysis 1.Diesel engine shut down relay no action. 2.diesel engine solenoid is broken. Troubleshooting 〈1〉Measure the Diesel engine shutdown relay with a multi-meter, the normal working voltage is 25.5 V, if relay no acti...Read more -
Failure analysis and solution if diesel genset engine exhaust smoke is not normal
Normal operation of diesel engine with load, exhaust smoke color is light gray commonly, when the load is a little heavy, may be to dark grey. Here exhaust smoke color abnormal refers toexhaust smoke is black or exhaust smoke is white or exhaust smoke is blue. 1、Smoke black indicate the combust...Read more -
Failure analysis and solution for the engine of diesel generator set can not start
There are various reasons can not start the engine of diesel genset. Mainly in the following four points: 1.start system Failure Analysis A.Start battery voltage is low, the actual capacity is not enough (shows the voltage as virtual voltage) B.Start battery cable and motor wiring error C.S...Read more -
What is the cause of the smoke in the diesel generator set?
Diesel generator sets may emit smoke during operation. Different colors of smoke represent different faults. If the smoke of the diesel generator set is not dealt with in time, it may cause the failure of the diesel generator set or even the failure to start. Here are some of the smoky condition...Read more -
Preparations for unit installation
1.Unit handling In the handling should pay attention to the lifting rope should be tied in the appropriate position, hanging lightly. When the unit is transported to the destination, it should be placed in the warehouse as far as possible. If there is no warehouse to be stored in the open air, t...Read more -
Management for generating room and responsibility for operator
Management system for diesel generator room 1.First, the electrician must use the generator correctly according to the operation rules, do a good job in the maintenance of the generator usually, make a good record when genst operating every time. 2.Check all parts of the generator, coolant, fuel...Read more
